Toyota 4 Runner/Hilux/Surf

1987-1998 of release

Repair and car operation


Тойота 4Раннер
+ 1. The maintenance instruction
+ 2. Maintenance service
+ 3. Engines
+ 4. Systems of heating, ventilation
+ 5. Fuel and exhaust systems
+ 6. Transmissions
+ 7. Transmission elements
+ 8. Brake system
+ 9. A suspension bracket and a steering
+ 10. A body
- 11. An electric equipment
   11.1. Specifications
   11.2. The battery
   + 11.3. Ignition system
   11.4. The coil () ignitions
   11.5. The ignition distributor
   11.6. Check and installation of the moment of ignition
   11.7. The block of electronic ignition
   11.8. The induction gauge
   - 11.9. System of a charge of the battery
      11.9.1. Check of system of a charge of the battery
   + 11.10. The generator
   11.11. System of start-up of the engine
   + 11.12. The starter electric motor
   11.13. The traction relay
   11.14. Pressure check
   11.15. Short circuit detection
   11.16. Check of reliability of grounding
   11.17. Check of integrity of a chain
   11.18. A finding of not closed chain
   11.19. Search of malfunctions
   11.20. Safety locks
   11.21. Fusible crosspieces
   11.22. Breakers
   11.23. The relay
   11.24. The breaker of indexes of turn / of the alarm system
   11.25. The switch of indexes of turn
   11.26. The lock of ignition and a lock drum
   11.27. The switch of external illumination
   11.28. The screen wiper switch
   11.29. Lamps of headlights
   11.30. Adjustment of headlights
   11.31. The headlight case
   11.32. Replacement of lamps
   11.33. The receiver and dynamics
   11.34. The aerial
   + 11.35. The screen wiper electric motor
   11.36. The switch of heating of back glass
   11.37. A heater of back glass
   11.38. A guard of devices
   11.39. A sound signal
   11.40. The electric drive of mirrors
   11.41. Cruise-control
   + 11.42. The electric drive window lifterа
   11.43. The electric drive of door-locks
   11.44. Safety pillows
+ 12. Electroschemes

11.9. System of a charge of the battery
THE GENERAL DATA

System of a charge of the battery
1. The ignition key
2. A fusible insert on 10 And
3. A control lamp of a charge
4. A winding статора
5. A rotor winding
 6. The generator
7. A pressure regulator
8. The battery
9. The main fusible crosspiece

Typical arrangement of fusible inserts
1. Connecting box N 1
2. The assembly block
3. The processor block
4. Fusible insert STOP on 15 And
5. Fusible insert IGN on 15 And
6. Fusible insert GAUGE on 10 And
 7. A fusible insert of the processor
The block on 15 And
8. The main relay
9. Fusible insert АМ1 on 40 And
10. Fusible insert АМ2 on 30 And
11. Fusible insert ALT FL on 80 And

Cистема a charge consists of the generator of an alternating current, a regulator of pressure, the battery, a fusible crosspiece and connecting wires. At teamwork of these devices a food of such consumers as ignition system, illumination and alarm system devices is provided, the radio receiver, etc. a generator Drive is carried out from a belt in a forward part of the engine.

The pressure regulator is intended for maintenance of pressure of the generator at the set level. At sharp increase of pressure on an exit of the generator the regulator prevents throws of a current and an overload in a feed circuit. Periodic care of charge system as a rule it is not required. However, it is necessary to examine periodically a belt of a drive of the generator, the battery and connecting wires. The control lamp of a charge on the panel of devices lights up at inclusion of ignition and after engine start-up dies away. If the lamp does not die away after engine start-up in a charge chain it is faulty. Some cars are equipped with the voltmeter. If the voltmeter shows very high or very much a low voltage the charge chain requires check.

Safety measures

At connections of wires of an onboard network of the car and external devices it is necessary to observe following safety measures.

At connection of the battery with the generator always observe polarity of connection.

Before repair of any site of the car by electric welding disconnect wires from the generator and the battery.

It is forbidden to start the engine at connected зарядном the device.

The generator is attached directly to the battery, therefore at закорачивании generator conclusions, or at its overload, formation of an arch and a fire is possible.


On the main page